Scottish Aviation Twin Pioneer

The Scottish Aviation Twin Pioneer was a British STOL transport aircraft built by Scottish Aviation Limited at Prestwick Airport, Scotland, during the 1950s. It was designed for both civil and military operators. It was conceived as a twin-engined version of the Pioneer light transport. Both aircraft required "an area only 30m (99ft) by 275m (902ft) in which to operate."

Design and development
Powered by two Alvis Leonides radial engines, the Twin Pioneer was a high-wing cabin monoplane with a triple fin and rudder assembly and fixed tailwheel undercarriage. The prototype Twin Pioneer, registered G-ANTP, first flew at Prestwick Airport on 25 June 1955. Flight trials demonstrated that the aircraft had a very short landing run and the aircraft was displayed at the September 1955 Society of British Aircraft Constructors Show at Farnborough.

Three pre-production aircraft were built for trials, and sales and demonstrations.

In 1958, the 33rd aircraft was used as a prototype for the Series 2 with Pratt & Whitney Wasp R-1340 radial engines of which 5 had been ordered by Philippine Air Lines. In 1959, a Series 3 version was developed to use the improved Alvis Leonides 531 radial engine.

Early in its operational life in 1957 the Twin Pioneer suffered two fatal accidents due to fatigue failure which caused the outer panel of the wing to detach from the aircraft in flight. This issue required significant re-design of the structure and adversely impacted sales.

Operational history
The military version could carry external stores such as bombs under the stub wings. One aircraft became the first aircraft for the newly formed Royal Malaysian Air Force when it was delivered on 16 January 1962; the type served with the air force for 12 years.

The Royal Air Force ordered 39 aircraft, which were built between 1958 and 1959, deployed in Aden and the Far East. It was used extensively by British forces in the Malayan Emergency and the later confrontation in Borneo. In August 1959, No. 78 Squadron RAF at Khormaksar received some Twin Pioneers to supplement its single engine Pioneers. The Twin Pioneers were employed in moving troops and supplies around the wilderness and on occasions lending support to the Sultan of Oman. A series of double engine failures caused problems with the squadron losing two aircraft on the same day. Unsuitable soft and hard landing strips were also causes of failures during landings.

Other squadrons that operated the Twin Pioneers were No. 152 Squadron RAF based at Muharraq in Bahrain and No. 21 Squadron RAF, which reformed with the type at Benson in May 1959. The squadron then moved to Kenya and in June 1965 to Aden. No. 152 operated around the Persian Gulf and in 1959, No. 209 Squadron RAF based at Seletar began to receive Twin Pioneers. These operated in Borneo and Malaya. The SRCU (Short Range Conversion Unit) at RAF Odiham also flew three Twin Pioneers for aircrew training. RAF No. 230 Squadron in the UK was the last military operator of the Twin Pioneer. The squadron operated the type in an interesting sand-colour camouflage scheme.

Although mainly used in military operations, the Twin Pioneer was also successful as a commercial transport for operation in areas without proper airfields, where unprepared surfaces were often the norm. Twin Pioneers were sold as survey aircraft to oil exploration companies with some of the first sales to Rio Tinto Finance and Exploration Limited, and the Austrian and Swiss government survey departments. Three were used by the 'Kroonduif' in Dutch New Guinea.

One Twin Pioneer served as a STOL training aircraft with the Empire Test Pilot School (ETPS) at RAE Farnborough for many years.

Variants

 * Twin Pioneer : Prototype aircraft with 540 hp Alvis Leonides 503 radial engines, one built.
 * Twin Pioneer Series 1 : Production aircraft with 560 hpAlvis Leonides 514 radial engines, 23 built.
 * Twin Pioneer CC.Mk 1 : Military version of the Series 1 for the Royal Air Force, 32 built.
 * Twin Pioneer Series 2 : Production aircraft with 600 hp Pratt & Whitney R-1340 radial engines, 6 built.
 * Twin Pioneer Series 3 : Production aircraft with 640 hp Alvis Leonides 531 radial engines, 18 built.
 * Twin Pioneer CC.Mk 2 : Military version of the Series 3 for the Royal Air Force, 7 built.

Many Series 1 aircraft were subsequently converted to Series 3 standard, including the prototype and all the remaining RAF CC.Mk 1 aircraft.

Civil operators
🇦🇺 Australia


 * Twin Pioneer Air
 * Capricorn Air

🇦🇹 Austria


 * Austrian Airlines

🇨🇦 Canada


 * Eastern Provincial Airways

🇪🇨 Ecuador


 * TAME

🇮🇸 Iceland


 * Flugfélag Íslands

🇮🇩 Indonesia


 * Garuda Indonesia
 * Merpati Nusantara Airlines

🇮🇷 Iran


 * Civil Aviation Club of Iran

🇮🇶 Iraq


 * Iraqi Airways

🇰🇼 Kuwait


 * Kuwait Airways

 Laos


 * Royal Air Lao

🇲🇾 Malaysia


 * Malaysia–Singapore Airlines

🇳🇵 Nepal


 * Royal Nepal Airlines

 Netherlands New Guinea


 * De Kroonduif

🇳🇬 Nigeria


 * Nigeria Airways

 Crown Colony of North Borneo


 * Borneo Airways

🇳🇴 Norway


 * Fjellfly

🇵🇭 Philippines


 * Philippines Airlines

🇸🇱 Sierra Leone


 * Sierra Leone Airways

🇨🇭 Switzerland


 * Swissair




 * Air Atlantique (Classic Air Force)
 * JF Airlines
 * Flight One Ltd.

Military operators

 * 🇮🇩 Indonesia
 * Indonesian Air Force
 * 🇲🇾 Malaysia
 * Royal Malaysian Air Force received 15 aircraft.
 * 🇳🇵 Nepal
 * 🇴🇲 Oman
 * Sultan of Oman's Air Force
 * Royal Air Force
 * No. 21 Squadron RAF (RAF Eastleigh then RAF Khormaksar – May 1959 to September 1967)
 * No. 78 Squadron RAF (RAF Khormaksar – October 1958 to June 1965)
 * No. 152 Squadron RAF (RAF Muharraq – December 1958 to June 1965)
 * No. 209 Squadron RAF (RAF Seletar – March 1959 to December 1968)
 * No. 225 Squadron RAF
 * No. 230 Squadron RAF (RAF Odiham – January 1960 to December 1961)
 * No. 224 Group Support Flight
 * No. 1310 Flight RAF
 * RAF Katuanayake Station Flight operated one aircraft.
 * RAF Odiham Station Flight
 * Empire Test Pilots' School operated one aircraft from 1965 to 1974.
 * Short Range Conversion Unit (RAF Odiham)
 * Short Range Conversion Unit (RAF Odiham)

Australia

 * Twin Pioneer Mk 3 VH-SYS is airworthy in the collection of the Historical Aircraft Restoration Society at Shellharbour Airport near Wollongong, New South Wales
 * Twin Pioneer Mk 3 VH-EVC at Walker's Aviation Museum, Barellan, New South Wales

A Mk 1 aircraft is privately owned and is in open storage on a private airfield in Queensland

Indonesia

 * Twin Pioneer Mk 1 PK-GTB (ex JZ-PPZ) at Manuhua Air Force Base, Biak Numfor Regency, Papua

Malaysia

 * On display
 * Twin Pioneer Mk 3 FM1064 at the Melaka Transport Museum

Twin Pioneer Mk 3 FM1001 is in the collection of the Royal Malaysian Air Force Museum, located since 2021 at RMAF Sendayan, but the museum is closed

United Kingdom

 * On display
 * Twin Pioneer CC.1 XL993 at the Royal Air Force Museum Cosford, Shropshire, England.
 * Twin Pioneer Mk 2 G-BBVF at the National Museum of Flight, East Fortune, Scotland.


 * Stored or under restoration
 * Twin Pioneer Mk 3 G-AZHJ has been acquired by the South Wales Aviation Museum at St Athan for restoration as a museum exhibit.

Twin Pioneer Mk 2 G-APRS (G-BCWF) was airworthy in the collection of the Classic Air Force, Coventry, England. It was transported to Stirling, Scotland in July 2018 to be converted to a 'glamping' home.

Incidents and accidents

 * Structural failure caused the first Twin Pioneer crash, of JZ-PPX operated by Kroonduif of Indonesia on 30 Aug 1957 about 8 miles off Japen Island, Papua New Guinea, both occupants died.
 * The same structural failure also caused the second Twin Pioneer crash, of G-AOEO operated by Scottish Airlines on 7 Dec 1957 near Fezzan, Libya, all 6 on board died, including David McKintyre, the co-founder of Scottish Aviation Limited and a driving force behind the company.
 * On 10 March 1960, G-ANTP, operated by Scottish Airlines, crashed on take-off at Jorhat-Rowriah Airport, India, killing all 3 persons on board.
 * A recorded loss of a Twin Pioneer occurred on takeoff from Limbang Airport on 17 May 1967. The aircraft, operated by Malaysia-Singapore Airlines, carried the registration 9M-ANC. The cause was given as unknown.
 * In Royal Air Force service three aircraft had fatal accidents:
 * 2 March 1961 – XL966 of 21 Squadron flew into rising ground at Mount Meru, Tanganyika, Tanzania, one killed.
 * 14 February 1963 – XN318 of 209 Squadron flew into a wooded cliff in Borneo, all five onboard killed.
 * 18 April 1963 – XL994 of 152 Squadron dived into the ground near Bu Hafafa in Oman, all eight onboard killed.
 * Two aircraft had accidents while being operated by Garuda Indonesian Airways:
 * On 14 May 1963, the Scottish Aviation Twin Pioneer 3, PK-GTC Garuda Indonesian Airways, damaged beyond repair. No one injuries.
 * On 20 September 1963, a Scottish Aviation Twin Pioneer 1, registration PK-GTB Garuda Indonesian Airways, crashed into terrain. Other reports say this Twin Pioneer was damaged on landing. Killed all 7 people on board.