Tupolev Tu-91

The Tupolev Tu-91 (NATO reporting name Boot) was a two-seat Soviet attack aircraft built during the 1950s. It was initially designed as a carrier-borne aircraft, but was converted into a land-based aircraft after Joseph Stalin's death in 1953 cancelled the aircraft carriers being designed. Two prototypes had been built and production had been approved by the Soviet Navy when it was inspected by the General Secretary, Nikita Khrushchev, in 1956. He remarked how ridiculous the Tu-91 looked and the program was cancelled.

Development
Following the end of World War II in 1945, Stalin ordered an aggressive naval expansion to counter the American naval superiority. The expansion called for building a large number of warships oriented around battleships and other heavy ships, with aircraft carriers limited to a supporting role, despite Admiral of the Fleet Nikolai Kuznetsov, Commander-in-chief of the Soviet Navy, pushing for carriers. Stalin restored him to command of the navy in 1951, after having demoted him four years before, and Kuznetsov attempted to persuade him of the value of the carrier in 1952, but Stalin refused to make a decision before his death the following year.

Kuznetsov had ordered preliminary design work to begin on the Project 85 light aircraft carrier and the aircraft for the ship before Stalin's death, although the ship was never more than a paper design. This allowed the Tupolev Design bureau to decide upon on a single-engined turboprop aircraft to meet Soviet Naval Aviation's requirement for a long-range strike aircraft, capable of attacking targets with bombs or torpedoes. The new leaders of the Soviet Union rejected proposals for carriers and the Council of Ministers issued a requirement for a land-based bomber powered by a Kuznetsov TV-2 turboprop engine that was capable of level and dive bombing attacks on targets with bombs, torpedoes, rockets, gunfire and naval mines, in addition to coastal reconnaissance missions on 29 April 1953. This forced the bureau to revise the design to eliminate the wing-folding mechanism, arresting gear and other carrier-specific equipment for the second prototype.

The Tu-91 first flew on 17 May 1955, when the manufacturer's flight testing began. They concluded successfully about September with the test pilots concluding that the aircraft was highly manoeuverable, although barrel rolls should be forbidden. The aircraft also passed the subsequent state testing and the design bureau began preparing for production at Factory No. 31, in Tbilisi, Georgia. The Tu-91 was part of a display of the latest military aircraft for the Soviet leadership in mid-1956, one of the very few propeller-driven aircraft present. When the newly elected Khrushchev inquired about the aircraft, the officer detailed to the aircraft misspoke, stating that it could do the job of a heavy cruiser rather than it had the firepower of that ship. Khrushchev replied, "But nobody needs heavy cruisers any more", and commented how ridiculous it looked. This off-hand comment caused the program to be cancelled.

Description
The Tu-91 was a duralumin low-winged monoplane with dihedral wings built from three spars. The wing consisted of three sections, two outer panels and the center section that housed four fuel tanks and the tricycle landing gear. Control surfaces on the outer panels consisted of manually tabbed ailerons and slotted flaps. The aircraft had a conventional tail structure with vertical and horizontal stabilisers. The engine was mounted mid-fuselage above the wing spars, driving a six-bladed contra-rotating propeller in the nose via a long shaft that passed through the cockpit. Providing sufficient air to the engine required a lot of development time that eventually included replacing an engine on a Tupolev Tu-4LL flying testbed with a mockup of the Tu-91's nose with a working TV-2 installation. The solution adopted consisted of three air intakes: a chin inlet and two cheek inlets below the cockpit that met in a plenum chamber forward of the engine. The engine exhausted through a bifurcated exhaust duct that exited the sides of the fuselage aft of the wing.

The crew of two sat side by side in a cockpit in the aircraft's nose, enclosed in an armour "bathtub" that consisted of 8 to 18 mm ANBA-1 light alloy armour. All of the panels in the two canopies were bulletproof except for those directly overhead. In addition to the forward fuel tanks, there were another pair of tanks located between the exhaust ducts, all of which self sealing and filled with inert gases. The internal armament of the Tu-91 consisted of a pair of 23 mm NR-23 cannon located in the wing roots and another pair of NR-23s in a DK-15 powered tail turret that were remotely controlled by the aircraft's navigator using a periscopic gunsight mounted externally above the cockpit. The aircraft could be fitted with five plyons, one under the fuselage and the others under the wings. These could carry a single torpedo or various bombs, rockets and mines up to a total weight of 1500 kg. Two of the wing pylons were plumbed to carry drop tanks in addition to weapons. A camera was fitted in the rear fuselage for reconnaissance missions.