Akutan Zero



The Akutan Zero, also known as Koga's Zero (古賀のゼロ) and the Aleutian Zero, was a type 0 model 21 Mitsubishi A6M Zero Japanese fighter aircraft piloted by Petty Officer Tadayoshi Koga, that crash-landed on Akutan Island, Alaska Territory, during World War II. It was found intact by the Americans in July 1942 and became the first Zero acquired by the United States during the war that could be restored to airworthy condition. It was repaired and flown by American test pilots. As a result of information gained from these tests, American tacticians were able to devise ways to defeat the Zero, which was the Imperial Japanese Navy's primary fighter plane throughout the war.

The Akutan Zero has been described as "a prize almost beyond value to the United States", and "probably one of the greatest prizes of the Pacific War". Japanese historian and JASDF lieutenant general Masatake Okumiya stated that the acquisition of the Akutan Zero "was no less serious" than the Japanese defeat at the Battle of Midway, and that it "did much to hasten Japan's final defeat". Nonetheless, historian John Lundstrom and others challenge "the contention that it took dissection of Koga's Zero to create tactics that beat the fabled airplane".

The Akutan Zero was destroyed in a training accident in 1945. Parts of it are preserved in several museums in the United States.

Mitsubishi A6M Zero fighter


The Second Sino-Japanese War began in 1937. Attacks by Chinese fighter planes on Japanese bombers led the Japanese to develop the concept of fighter escorts. The limited range of the Mitsubishi A5M "Claude" fighter used to escort the bombers caused the Japanese Navy Air staff to commission the Mitsubishi A6M Zero as a long-range land- and carrier-based fighter.

The Zero, which first flew in 1939, was exceedingly agile and lightweight, with maneuverability and range superior to any other fighter in the world at that time. In 1940 Claire Lee Chennault, leader of the Flying Tigers, wrote a report to warn his home country of the Zero's performance. However, United States Department of War analysts rejected the Chennault report as "arrant nonsense" and concluded the performance attributed to the Zero was an aerodynamic impossibility. With the coming of war, the U.S. fighting services learned better; the Zero's maneuverability outperformed any Allied fighter it encountered for the first two years of the war. According to American flying ace William N. Leonard, "In these early encounters and on our own we were learning the folly of dogfighting with the Zero".

To achieve this dogfighting agility, however, Japanese engineers had traded off durability. The Zero was very lightly built; it had no armor and no self-sealing fuel tanks. According to American author Jim Rearden, "The Zero was probably the easiest fighter of any in World War II to bring down when hit ... The Japanese ... were not prepared to or weren't capable of building more advanced fighters in the numbers needed to cope with increasing numbers and quality of American fighters". The Zero was the primary Japanese Navy fighter throughout the war. During the war, the Japanese manufactured roughly 10,500 Zeros.

Nine Zeros were shot down during the attack on Pearl Harbor. From these wrecks, the Allies learned that the Zero lacked armor and self-sealing fuel tanks, but little else about its capabilities. The Zero's flight performance characteristics—crucial to devising tactics and machinery to combat it—remained a mystery.

Three other downed Zeros were available to the Allies before the Akutan Zero was recovered. In February 1942, a Zero (serial number 5349) piloted by Hajime Toyoshima crashed on Melville Island in Australia after the bombing of Darwin; it was heavily damaged. Another Zero, piloted by Yoshimitsu Maeda, crashed near Cape Rodney, New Guinea. The team sent to recover the plane erred when they chopped off the wings, severing the wing spars and rendering the hulk unflyable. The third came from China, where Gerhard Neumann reconstructed a working aircraft from a partly intact Zero (serial number 3372) that had landed in Chinese territory plus salvaged pieces from other downed Zeros. Neumann's aircraft did not reach the United States for testing until after the recovery of the Akutan Zero.

Petty Officer Koga's final mission


In June 1942, as part of the Japanese Midway operation, the Japanese attacked the Aleutian islands, off the south coast of Alaska. A Japanese task force led by Admiral Kakuji Kakuta bombed Dutch Harbor on Unalaska Island twice, once on June 3 and again the following day.

Tadayoshi Koga (September 10, 1922 – June 4, 1942), a 19-year-old flight petty officer first class, was launched from the Japanese aircraft carrier JAPANESE AIRCRAFT CARRIER Ryūjō as part of the June 4 raid. Koga was part of a three-plane section; his wingmen were Chief Petty Officer Makoto Endo and Petty Officer Tsuguo Shikada. Koga and his comrades attacked Dutch Harbor, and are believed to be the three Zeroes that shot down an American PBY-5A Catalina flying boat piloted by Bud Mitchell, and strafed its survivors in the water, killing Mitchell and all six of his crewmen. In the process, Koga's plane (serial number 4593) was damaged by small arms fire.

Tsuguo Shikada, one of Koga's wingmen, published an account in 1984 in which he claimed the damage to Koga's plane occurred while his section was making an attack against two American Catalinas anchored in the bay. This account omits any mention of shooting down Mitchell's PBY. Both American and Japanese records contradict his claims; there were no PBYs in the bay that day. However, his claims do match American records from the attack against Dutch Harbor the previous day (June 3). Rearden noted, "It seems likely that in the near half-century after the event Shikada's memory confused the raids of June 3 and June 4 ... It also seems likely that in his interview, Shikada employed selective memory in not mentioning shooting down Mitchell's PBY and then machine-gunning the crew on the water".

It is not known who fired the shot that brought down Koga's plane, although numerous individuals have claimed credit. Photographic evidence strongly suggests it was hit by ground fire. Members of the 206th Coast Artillery Regiment, which had both 3-inch anti-aircraft guns and .50-caliber machine guns in position defending Dutch Harbor, claimed credit, in addition to claims made by United States Navy ships that were present. Physical inspection of the plane revealed it was hit with small arms fire: .50 caliber bullet holes and smaller, from both above and below.

Crash
The fatal shot severed the return oil line, and Koga's plane immediately began trailing oil. Koga reduced speed to keep the engine from seizing for as long as possible. "The three Zeros flew to Akutan Island, 25 miles east of Dutch Harbor, which had been designated for emergency landings. Waiting near the island was a Japanese submarine assigned to pick up downed pilots. At Akutan, the three Zeros circled a grassy flat half a mile inland from Broad Bight. Shikada thought the ground was firm beneath the grass, but in his second pass he noticed water glistening. He suddenly realized Koga should make a belly landing. But by then Koga had lowered his landing gear and was almost down."

The plane's landing gear mired in the water and mud, causing the plane to flip upside down and skid to a stop. Although the aircraft survived the landing nearly intact, Petty Officer Koga died instantly on impact, probably from a broken neck or a blunt-force blow to his head. Koga's wingmen, circling above, had orders to destroy any Zeros that crash-landed in enemy territory, but as they did not know if Koga was still alive, they could not bring themselves to strafe his plane. They decided to leave without firing on it. The Japanese submarine stationed off Akutan Island to pick up pilots searched for Koga in vain before being driven off by the destroyer USS Williamson (DD-244).

Recovery


The crash site, which was out of sight of standard flight lanes and not visible by ship, remained undetected and undisturbed for over a month. On July 10, 1942, an American PBY Catalina piloted by Lieutenant William "Bill" Thies spotted the wreckage. Thies's Catalina had been patrolling by dead reckoning and had become lost. On spotting the Shumagin Islands, he reoriented his plane and began to return to Dutch Harbor by the most direct course: over Akutan Island. Machinist Mate Albert Knack, who was the plane captain (note: the term "plane captain" in US Navy usage refers to an aircraft's assigned maintenance crew chief, not the pilot-in-command), spotted Koga's wreck. Thies's plane circled the crash site for several minutes, noted its position on the map, and returned to Dutch Harbor to report it. Thies persuaded his commanding officer, Paul Foley, to let him return with a salvage team. The next day (July 11), the team flew out to inspect the wreck. Navy photographer's mate Arthur W. Bauman took pictures as they worked.

Thies's team extracted Koga's body from the plane by having Knack (the smallest crew member) crawl up inside the plane and cut his safety harness with a knife. They searched it for anything with intelligence value, and buried Koga in a shallow grave near the crash site. Thies returned with his team to Dutch Harbor, where he reported the plane as salvageable. The next day (July 12), a salvage team under Lieutenant Robert Kirmse was dispatched to Akutan. This team gave Koga a Christian burial in a nearby knoll and set about recovering the plane, but the lack of heavy equipment (which they had been unable to unload after the delivery ship lost two anchors) frustrated their efforts. On July 15, a third recovery team was dispatched. This time, with proper heavy equipment, the team was able to free the Zero from the mud and haul it overland to a nearby barge, without further damaging it. The Zero was taken to Dutch Harbor, turned right-side up, and cleaned.



The Akutan Zero was loaded onto the USS St. Mihiel (AP-32) and transported to Seattle, arriving on August 1. From there, it was transported by barge to Naval Air Station North Island near San Diego where repairs were carefully carried out. These repairs "consisted mostly of straightening the vertical stabilizer, rudder, wing tips, flaps, and canopy. The sheared-off landing struts needed more extensive work. The three-blade Sumitomo propeller was dressed and re-used." The Zero's red Hinomaru roundel was repainted with the American blue-circle-white-star insignia. The whole time, the plane was kept under 24-hour military police guard in order to deter would-be souvenir hunters from damaging the plane. The Zero was fit to fly again on September 20.

Analysis


Data from the captured Zero had been transmitted to the U.S. Navy's Bureau of Aeronautics (BuAer) and Grumman Aircraft. After careful study, Roy Grumman decided that he could design an aircraft that could match or surpass the Zero in most respects, except range, without sacrificing pilot armor, self-sealing fuel tanks, and a sturdy fuselage structure. The new F6F Hellcat would compensate for the extra weight with additional power.

On September 20, 1942, two months after the Zero's capture, Lieutenant Commander Eddie R. Sanders took the Akutan Zero up for its first test flight. He made 24 test flights between September 20 and October 15. According to Sanders' report:

"These flights covered performance tests such as we do on planes undergoing Navy tests. The very first flight exposed weaknesses of the Zero which our pilots could exploit with proper tactics ... immediately apparent was the fact that the ailerons froze up at speeds above 200 knots so that rolling maneuvers at those speeds were slow and required much force on the control stick. It rolled to the left much easier than to the right. Also, its engine cut out under negative acceleration due to its float-type carburetor. We now had the answer for our pilots who were being outmaneuvered and unable to escape a pursuing Zero: Go into a vertical power dive, using negative acceleration if possible to open the range while the Zero's engine was stopped by the acceleration. At about 200 knots, roll hard right before the Zero pilot could get his sights lined up."

In early 1943, the Zero was transferred from Naval Air Station North Island to Anacostia Naval Air Station. The Navy wished to make use of the expertise of the NACA Langley Research Center in flight instrumentation, and it was flown to Langley on March 5, 1943, for the installation of the instrumentation. While there, it underwent aerodynamic tests in the Full-Scale Wind Tunnel under conditions of strict secrecy. This work included wake surveys to determine the drag of aircraft components; tunnel scale measurements of lift, drag, control effectiveness; and sideslip tests.

After its return to the Navy, it was flight tested by Frederick M. Trapnell, the Anacostia Naval Air Station director of flight testing. He flew the Akutan Zero in performance maneuvers while Sanders simultaneously flew American planes performing identical maneuvers, simulating aerial combat. Following these, USN test pilot Lieutenant Melvin C. "Boogey" Hoffman conducted more dogfighting tests between himself flying the Akutan Zero and recently commissioned USN pilots flying newer Navy aircraft.

Later in 1943, the aircraft was displayed at Washington National Airport as a war prize. In 1944, it was recalled to North Island for use as a training plane for rookie pilots being sent to the Pacific. A model 52 Zero, captured during the liberation of Guam, was later used as well.

Data and conclusions from these tests were published in Informational Intelligence Summary 59, Technical Aviation Intelligence Brief #3, Tactical and Technical Trends #5 (published prior to the first test flight), and Informational Intelligence Summary 85. These results tend to somewhat understate the Zero's capabilities.

Consequences
Data from the captured aircraft were submitted to the BuAer and Grumman for study in 1942. The U.S. carrier-borne fighter plane that succeeded the Grumman F4F Wildcat, the F6F Hellcat, was tested in its first experimental mode as the XF6F-1 prototype with an under-powered Wright R-2600 Twin Cyclone 14-cylinder, two-row radial engine on 26 June 1942. Shortly before the XF6F-1's first flight, and based on combat accounts of encounters between the F4F Wildcat and A6M Zero, on 26 April 1942, BuAer directed Grumman to install the more powerful 18-cylinder Pratt & Whitney R-2800 Double Wasp radial engine—already powering Chance Vought's Corsair design since its beginnings in 1940—in the second XF6F-1 prototype. Grumman complied by redesigning and strengthening the F6F airframe to incorporate the 2,000 hp (1,500 kW) R-2800-10 engine, driving a three-bladed Hamilton Standard propeller. With this combination, Grumman estimated the XF6F-3's performance would surpass that of the XF6F-1 by 25%. This first Double Wasp-equipped Hellcat airframe, bearing BuAer serial number 02982, first flew on 30 July 1942. The F6F-3 subtype had been designed with specific "Wildcat vs Zero" input from F4F pilots who fought in the Battle of the Coral Sea, such as Jim Flatley, and the Battle of Midway, such as Jimmy Thach; their input was obtained during a meeting with Grumman Vice President Jake Swirbul at Pearl Harbor on 23 June 1942. The first production F6F-3 made its first flight just over three months later, on October 3, 1942. While the captured Zero's tests did not drastically influence the Hellcat's design, they did impart knowledge of the Zero's handling characteristics, including its limitations in rolling right and diving. That information, together with the improved capabilities of the Hellcat, were credited with helping American pilots "tip the balance in the Pacific". American aces Kenneth A. Walsh and R. Robert Porter, among others, credited tactics derived from this knowledge with saving their lives. James Sargent Russell, who commanded the PBY Catalina squadron that discovered the Zero and later rose to the rank of admiral, said that Koga's Zero was "of tremendous historical significance". William N. Leonard concurred: "The captured Zero was a treasure. To my knowledge, no other captured machine has ever unlocked so many secrets at a time when the need was so great."

Some historians dispute the degree to which the Akutan Zero influenced the outcome of the air war in the Pacific. For example, the Thach Weave, a tactic created by John Thach and used with great success by American airmen against the Zero, was devised by Thach before the attack on Pearl Harbor, based on intelligence reports on the Zero's performance in China.



"The capture and flight tests of Koga's Zero is usually described as a tremendous coup for the Allies as it revealed the secrets of that mysterious aircraft and led directly to its downfall. According to this viewpoint, only then did Allied pilots learn how to deal with their nimble opponents. The Japanese could not agree more... Yet those naval pilots who fought the Zero at Coral Sea, Midway, and Guadalcanal without the benefit of test reports would beg to differ with the contention that it took dissection of Koga's Zero to create tactics that beat the fabled airplane. To them the Zero did not long remain a mystery plane. Word quickly circulated among the combat pilots as to its particular attributes. Indeed on 6 October while testing the Zero, Akutan Zero test pilot Frederick M. Trapnell made a highly revealing statement: 'The general impression of the airplane is exactly as originally created by intelligence—including the performance'."

Nine wrecked Mitsubishi A6M Zeros were recovered from Pearl Harbor shortly after the attack in December 1941, and United States Office of Naval Intelligence, along with BuAer had them studied, and then shipped to the Experimental Engineering Department at Dayton, Ohio in 1942. It was noted that the experimental Grumman XF6F-1s then undergoing testing in June 1942 and the Zero had "wings integrated with the fuselage," an unusual design feature in American aircraft of the day.

The Akutan Zero was destroyed during a training accident in February 1945. While the Zero was taxiing for a take-off, a Curtiss SB2C Helldiver lost control and rammed into it. The Helldiver's propeller sliced the Zero into pieces. From the wreckage, William N. Leonard salvaged several gauges, which he donated to the National Museum of the United States Navy. The Alaska Heritage Museum and the Smithsonian National Air and Space Museum also have small pieces of the Zero.

American author Jim Rearden led a search on Akutan in 1988 in an attempt to repatriate Koga's body. He located Koga's grave, but found it empty. Rearden and Japanese businessman Minoru Kawamoto conducted a records search. They found that Koga's body had been exhumed by an American Graves Registration Service team in 1947, and re-buried on Adak Island, further down the Aleutian chain. The team, unaware of Koga's identity, marked his body as unidentified. The Adak cemetery was excavated in 1953, and 236 bodies were returned to Japan. The body buried next to Koga (Shigeyoshi Shindo) was one of 13 identified; the remaining 223 unidentified remains were cremated and interred in Chidorigafuchi National Cemetery in Japan. It is probable that Koga was one of them.